Spartan-tough-duty-cleaner-degreaser
Spartan Chemical Company, Inc.
Material Safety Data Sheet
SECTION I: PRODUCT INFORMATION
| Product Name or Number (as it appears on label): |
Product Division: |
TOUGH DUTY
Product Number: 2040; 2041 |
Janitorial |
| Spartan Chemical Company, Inc. |
Product/Technical Information: |
1-(800)-537-8990 |
| 1110 Spartan Drive |
Medical Emergency: |
1-(888)-314-6171 (24 hours) |
| Maumee OH 43537 |
Chemical Leak/Spil Emergency: |
CHEMTREC 1-(800) 424-9300 (24 hours) |
| Shipping Description: |
Cleaning compounds, liquid, n.o.s. |
| NFPA Ratings: |
|
HMIS Ratings: |
|
| Health: |
2 - Moderate |
Health: |
2 - Moderate |
| Fire: |
0 - Minimal |
Fire: |
0 - Minimal |
| Reactivity: |
0 - Minimal |
Reactivity: |
0 - Minimal |
|
|
Pers. Prot. Equip.: |
B - Safety Glasses; gloves |
SECTION II: HAZARDOUS INGREDIENTS
(Listed when present at 1% or greater, carcinogens at 0.1% or greater) All component chemicals are listed or exempted from listing on the "TSCA Inventory" of chemical substances maintained by the U.S. Environmental Protection Agency.
| Chemical Name(s) |
% W
|
CAS Registry No.
|
Table Z- 1 - A
|
Carcinogen
|
|
TWA mg/m3
|
STEL mg/m 3
|
CELING mg/m3
|
| *2-Butoxyethanol |
9
|
111-76-2
|
120 [skin]
|
Not Established
|
Not Established
|
No
|
| Isopropanol |
01-05
|
67-63-0
|
980
|
1225
|
Not Established
|
No
|
| Nonyl phenol ethoxylate |
01-05
|
9016-45-9
|
Not Established
|
Not Established
|
Not Established
|
No
|
| Tetrasodium ethylene diaminetetraacetate |
01-05
|
64-02-8
|
Not Established
|
Not Established
|
Not Established
|
No
|
Comment: *This substance is subject to the reporting requirements of Section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 (SARA) and of 40 CFR 372.
SECTION III: PHYSICAL DATA
| Boiling Point: |
203 °F |
Vapor Pressure: |
Unknown |
| Vapor Density (AIR = 1): |
Unknown |
Solubility in Water: |
Complete |
| pH: |
11.5-12.0 |
Specific Gravity (H2O=1): |
1.005 |
| Evaporation Rate (but.ace.=1): |
<1 |
Percent Solid by Weight: |
1-5 |
| Physical State: |
Liquid |
|
|
| Appearance & Odor: |
Dark pink, non-viscous floral odor |
SECTION IV: FIRE & EXPLOSIVE HAZARD DATA
| Flash Point: |
None |
Method Used: |
ASTM-D56 |
| Flammable Limits: |
Not Established |
Flame Extension: |
N/A |
| Extinguishing Media: |
N/A |
| Special Fire Fighting Procedures: |
None |
| Unusual Fire & Explosive Hazards: |
None known |
SECTION V: HEALTH HAZARD DATA
| Threshold Limit Value: |
Not Established |
Primary Routes of Entry: |
Inhalation, Skin Contact |
Effects of Overexposure-
Conditions to Avoid: |
May cause skin and eye irritation. Avoid prolonged skin contact and inhalation of vapors or mist. Butoxyethanol is absorbed through the skin which may affect the liver, kidneys, lymph, and blood systems, inhalation may irritate throat and respiratory system. |
| Conditions Aggravated by Use: |
Unknown |
Emergency & First Aid Procedures:
| Eyes: |
In case of contact; immediately flush eyes with water for at least 15 minutes. Remove contact lenses. If irritation persists; seek medical attention. |
| Skin: |
For skin contact; immediately flush with water for 15 minutes. If irritation persists; seek medical attention. |
| Ingestion: |
If swallowed; drink large quantities of water or fruit juice. Call a physician immediately. |
SECTION VI: REACTIVITY DATA
| Stability: |
Stable |
Incompatible Materials: |
Avoid strong oxidizing agents. |
| Hazardous Decomposition Products: |
None known |
Hazardous Polymerization: |
Will Not Occur |
SECTION VII: SPILL OR LEAK PROCEDURES
Steps to be Taken in Case
Material is Released or Spilled: |
Flush with copious amounts of water into sanitary sewer system. |
| Waste Disposal Method: |
Same as above. |
SECTION VIII: SPECIAL PROTECTION INFORMATION
| Respiratory Protection: |
None required |
| Ventilation: |
Good general ventilation should be sufficient for most conditions. Local exhaust ventilation may be necessary for some operations. |
| Protective Gloves(Specify Type): |
Solvent resistant gloves |
| Eye Protection(Specify Type): |
Safety glasses |
| Other Protective Equipment: |
None |
SECTION IX: SPECIAL PRECAUTIONS
| Precautions; Handling & Storing: |
None |
| Other Precautions: |
None |
| © SCC 05/04/2000 |
Name: |
Ronald T. Cook |
Title: |
Manager, Regulatory Affairs |
| TOUGH DUTY |
Effective Date: |
05/04/2000 |
Supercedes: |
09/24/1999 |
| Ref: 29 CFR 1910.1200 (OSHA) |
Changes: |
NFPA & HMIS Correction, Update Section II |
| This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty, express or implied, as to the accuracy of the information contained herein. Actual conditions of use and handling are beyond sellers control. User is responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State and Local laws and regulations. |
